Cementitious, Pozzolanic And Filler Materials For DSM Binders
Abstract
Deep Soil Mix (DSM) is a proven method of ground improvement for deeper underlying soft soil layers which are otherwise impractical to reach using conventional shallow soil stabilization and replacement methods. The predominant binder materials used are Ordinary Portland cement (OPC) and Lime (CaO) but negative effects to the environment from manufacture and increasing construction cost have prompted research into alternative materials. This review identifies pozzolans and filler materials as possible supplements or partial substitutes for better results. The DSM method and binder reaction processes during treated soil strength development are outlined and effectiveness of different pozzolans (Fly Ash, Silica Fume, Ground Granulated Blast Furnace Slag, Rice Husk Ash, Kaolin, and Metakaolin) and filler materials (e.g. fine sand) discussed together with their influence factors. With many pozzolans, a clear optimum dosage is observed where improved strength peaks. Aluminosilicate pozzolans perform better over siliceous pozzolans with Metakaolin (MK) identified as the most effective pozzolan for enhancing compressive strength. Up to date research results on these materials are compiled. MK blended cements are readily available and can be readily applied for initial field tests. Treated soil strength may be regulated with addition of filler materials to further reduce reliance on cement.
Keywords
References
Harvey, C. Cement Producers Are Developing a Plan to Reduce CO2 Emissions. Scientific American, E & E News, Jul 09, 2018.
Geo-Solutions. Deep Soil Mixing Method Comparison. Available online: https://www.geo-solutions.com/wp-content/uploads/2017/05/17_Deep_Soil_Mixing_Method_Comparison.pdf. (accessed on 27 Dec., 2018).
Keller. Deep Soil Mixing (DSM): Improvement of Weak Soils by the DSM Method.
Hayashi, Hirochika, Jun’ichi Nishikawa, Kanta Ohishi, and Masaaki Terashi. “Field Observation of Long-Term Strength of Cement Treated Soil.” Grouting and Ground Treatment (January 29, 2003). doi:10.1061/40663(2003)32.
Lee, W., Im, J.-C., and Seo, M. “A Study on the Unconfined Compressive Strength of Improved Soil by DCM Method through Field Test.” Electronic Journal of Geotechnical Engineering, Vol. 23, No. 04, 2018, pp. 667–673.
Ruffing, D. G., M. J. Sheleheda, and R. M. Schindler. “A Case Study: Unreinforced Soil Mixing for Excavation Support and Bearing Capacity Improvement.” Grouting and Deep Mixing 2012 (August 17, 2012). doi:10.1061/9780784412350.0026.
Liu, Y., Jiang, Y. J., and Lee, F. H. “Determination of Representative Strength of Deep Cement-Mixed Clay from Core Strength Data.” Géotechnique, Vol. 67, No. 4, 2017, pp. 350–364. doi:10.1680/jgeot.16.P.105.
Vu, P. T. A. “Ground Improvement Using Soil-Cement Method: A Case Study with Laboratory Testing and In-Situ Verification for A Highway Project in Southern Vietnam.” Geotechnical Engineering Journal of the SEAGS & AGSSEA, Vol. 47, No. 1, 2016, pp. 45–49.
Janz, M., and Johansson, S.-E. “The Function of Different Binding Agents in Deep Stabilization.” Swedish deep stabilization research centre, report, Vol. 9, 2002, pp. 1–35.
Broms, Bengt B. “Stabilization of Soil with Lime Columns.” Foundation Engineering Handbook (1991): 833–855. doi:10.1007/978-1-4615-3928-5_24.
Ahnberg, H., and Johansson, S. “Increase in Strength with Time in Soils Stabilised with Different Types of Binder in Relation to the Type and Amount of Reaction Products.” Proceedings of Deep Mixing ‘05, Stockholm, 2005, pp. 195–202.
Arman, A., and Munfakh, G. A. “Lime Stabilization of Organic Soils.” Highway Research Record, Vol. 381, 1972, pp. 37–45.
Abdi, M. R., and Wild, S. “Sulphate Expansion of Lime-Stabilized Kaolinite: I. Physical Characteristics.” Clay Minerals, Vol. 28, No. 04, 1993, pp. 555–567. doi:10.1180/claymin.1993.028.4.06.
Kitazume, M., and Terashi, M. The Deep Mixing Method. CRC Press, 2013.
Bhattacharja, S., and Bhatty, J. “Comparative Performance of Portland Cement and Lime Stabilization of Moderate to High Plasticity Clay Soils.” Portl. Cem. Assoc, 2003.
Broms, BengtB. “Keynote Lecture: Design of Lime, Lime/cement and Cement Columns.” Dry Mix Methods for Deep Soil Stabilization (November 13, 2017): 125–154. doi:10.1201/9781315141466-17.
Kivelö, M., and B.B. Broms. “Mechanical Behaviour and Shear Resistance of Lime/cement Columns.” Dry Mix Methods for Deep Soil Stabilization (November 13, 2017): 193–200. doi:10.1201/9781315141466-23.
Hashim, R., and Islam, M. S. “Properties of Stabilized Peat by Soil-Cement Column Method.” Electronic Journal of Geotechnical Engineering, Vol. 13, 2008, pp. 1–9.
Islam, M. S., and Hashim, R. “Stabilization of Peat Soil by Soil-Column Technique and Settlement of the Group Columns.” International Journal of Physical Sciences, Vol. 5, No. 9, 2010, pp. 1411–1418.
Islam, S., and Hashim, R. “Bearing Capacity of Stabilised Tropical Peat by Deep Mixing Method.” 2009, p. 7.
Huat, B. B. K., Maail, S., and Mohamed, T. A. “Effect of Chemical Admixtures on the Engineering Properties of Tropical Peat Soils.” American Journal of Applied Sciences, Vol. 2, No. 7, 2005, pp. 1113–1120. doi:10.3844/ajassp.2005.1113.1120.
Huat, B. B., Kazemian, S., Prasad, A., and Barghchi, M. “A Study of the Compressibility Behavior of Peat Stabilized by DMM: Lab Model and FE Analysis.” Scientific Research and Essays, Vol. 6, No. 1, 2011, pp. 196–204.
Hampton, M. B., and Edil, T. B. Strength Gain of Organic Ground with Cement-Type Binders. Presented at the Soil improvement for big digs, 1998.
Hebib, S., and Farrell, E. R. “Some Experiences on the Stabilization of Irish Peats.” Canadian Geotechnical Journal, Vol. 40, No. 1, 2003, pp. 107–120. doi:10.1139/t02-091.
Uddin, K., Balasubramaniam, A. S., and Bergado, D. T. “Engineering Behavior of Cement-Treated Bangkok Soft Clay.” Geotechnical Engineering, Vol. 28, No. 1, 1997, pp. 89–119.
Kazemian, Sina, Afshin Asadi, Bujang B. K. Huat, Arun Prasad, and Irman B. A. Rahim. “Settlement Problems in Peat Due to Their High Compressibility and Possible Solution Using Cement Columns.” Forensic Engineering 2009 (November 2, 2009). doi:10.1061/41082(362)26.
Kitazume, Masaki, Takeshi Nakamura, Masaaki Terashi, and Kanta Ohishi. “Laboratory Tests on Long-Term Strength of Cement Treated Soil.” Grouting and Ground Treatment (January 29, 2003). doi:10.1061/40663(2003)31.
Xiao, H. W., Lee, F. H., and Kheng, G. H. “Yielding of Cement-Treated Marine Clay.” Soils and Foundations, Vol. 54, No. 3, 2014, pp. 488–501. doi:10.1016/j.sandf.2014.04.021.
Yao, K., Li, N., Chen, D. H., and Wang, W. “Generalized Hyperbolic Formula Capturing Curing Period Effect on Strength and Stiffness of Cemented Clay.” Construction and Building Materials, Vol. 199, 2019, pp. 63–71. doi:10.1016/j.conbuildmat.2018.11.288.
Malhotra, V. Mohan, and Povindar Kumar Mehta. Pozzolanic and cementitious materials. CRC Press, 2004.
Sargent, P. “The Development of Alkali-Activated Mixtures for Soil Stabilisation.” Handbook of Alkali-Activated Cements, Mortars and Concretes (2015): 555–604. doi:10.1533/9781782422884.4.555.
Duxson, P., Fernández-Jiménez, A., Provis, J. L., Lukey, G. C., Palomo, A., and van Deventer, J. S. J. “Geopolymer Technology: The Current State of the Art.” Journal of Materials Science, Vol. 42, No. 9, 2007, pp. 2917–2933. doi:10.1007/s10853-006-0637-z.
Cherian, C., and Arnepalli, D. N. “A Critical Appraisal of the Role of Clay Mineralogy in Lime Stabilization.” International Journal of Geosynthetics and Ground Engineering, Vol. 1, No. 1, 2015. doi:10.1007/s40891-015-0009-3.
Ikegami, M., Ichiba, T., Ohishi, K., and Terashi, M. Long-Term Properties of Cement Treated Soil 20 Years after Construction. Presented at the 16th International Conference on Soil Mechanics and Geotechnical Engineering, Osaka, 2005.
Frias, M., and Cabrera, J. “Pore Size Distribution and Degree of Hydration of Metakaolin–Cement Pastes.” Cement and Concrete Research, Vol. 30, No. 4, 2000, pp. 561–569. doi:10.1016/S0008-8846(00)00203-9.
Kamruzzaman, A. H., Chew, S. H., and Lee, F. H. “Structuration and Destructuration Behavior of Cement-Treated Singapore Marine Clay.” Journal of Geotechnical and Geoenvironmental Engineering, Vol. 135, No. 4, 2009, pp. 573–589. doi:10.1061/(ASCE)1090-0241(2009)135:4(573).
Sasanian, S., and Newson, T. A. “Basic Parameters Governing the Behaviour of Cement-Treated Clays.” Soils and Foundations, Vol. 54, No. 2, 2014, pp. 209–224. doi:10.1016/j.sandf.2014.02.011.
Correia, A., Venda Oliveira, P., and Lemos, L. Prediction of the Unconfined Compressive Strength in Soft Soil Chemically Stabilized. Presented at the Proc., 18th Int. Conf. on Soil Mechanics and Geotechnical Engineering, 2013.
Khan, S. U., Nuruddin, M. F., Ayub, T., and Shafiq, N. “Effects of Different Mineral Admixtures on the Properties of Fresh Concrete.” The Scientific World Journal, Vol. 2014, 2014, pp. 1–11. doi:10.1155/2014/986567.
Walker, R., and Pavía, S. “Physical Properties and Reactivity of Pozzolans, and Their Influence on the Properties of Lime–Pozzolan Pastes.” Materials and Structures, Vol. 44, No. 6, 2011, pp. 1139–1150. doi:10.1617/s11527-010-9689-2.
Quarcioni, V. A., Chotoli, F. F., Coelho, A. C. V., and Cincotto, M. A. “Indirect and Direct Chapelle’s Methods for the Determination of Lime Consumption in Pozzolanic Materials.” Revista IBRACON de Estruturas e Materiais, Vol. 8, No. 1, 2015, pp. 1–7. doi:10.1590/S1983-41952015000100002.
Yahaya, S., Jikan, S. S., Badarulzaman, N. A., and Adamu, A. D. “Chemical Composition and Particle Size Analysis of Kaolin.” Traektoriâ Nauki= Path of Science, Vol. 3, No. 10, 2017, pp. 1001–1004. doi:10.22178/pos.27-1.
Seco, A., F. Ramirez, L. Miqueleiz, P. Urmeneta, B. Garca, E. Prieto, and V. Oroz. “Types of Waste for the Production of Pozzolanic Materials – A Review.” Industrial Waste (March 7, 2012). doi:10.5772/36285.
Khan, S. U., Nuruddin, M. F., Ayub, T., and Shafiq, N. “Effects of Different Mineral Admixtures on the Properties of Fresh Concrete.” The Scientific World Journal, Vol. 2014, No. ID 986567, 2014, p. 11. doi:10.1155/2014/986567.
Fadzil, M. A., Muhd Nurhasri, M. S., Norliyati, M. A., Hamidah, M. S., Wan Ibrahim, M. H., and Assrul, R. Z. “Characterization of Kaolin as Nano Material for High Quality Construction.” MATEC WEb of Conferences (EDP Sciences), Vol. 103, 2017, p. 09019. doi:10.1051/matecconf/201710309019.
Axelsson, K. G., Johansson, S.-E., and Andersson, R. Stabilization of Organic Soils by Cement and Puzzolanic Reactions – Feasibility Study. Publication 3. Swedish Deep Stabilization Research Centre, 2002, pp. 1–51.
Tastan, E. O., Edil, T. B., Benson, C. H., and Aydilek, A. H. “Stabilization of Organic Soils with Fly Ash.” Journal of Geotechnical and Geoenvironmental Engineering, Vol. 137, No. 9, 2011, pp. 819–833. doi:10.1061/(ASCE)GT.1943-5606.0000502.
Phanikumar, B. R., and Nagaraju, T. V. “Engineering Behaviour of Expansive Clays Blended with Cement and GGBS.” Proceedings of the Institution of Civil Engineers - Ground Improvement, Vol. 171, No. 3, 2018, pp. 167–173. doi:10.1680/jgrim.17.00054.
Kalantari, B., Prasad, A., and Huat, B. B. K. “Stabilising Peat Soil with Cement and Silica Fume.” Proceedings of the Institution of Civil Engineers - Geotechnical Engineering, Vol. 164, No. 1, 2011, pp. 33–39. doi:10.1680/geng.900044.
Kalantari, B., Prasad, A., and Huat, B. B. K. “Cement and Silica Fume Treated Columns to Improve Peat Ground.” Arabian Journal for Science and Engineering, Vol. 38, No. 4, 2013, pp. 805–816. doi:10.1007/s13369-012-0369-0.
Basha, E. A., Hashim, R., Mahmud, H. B., and Muntohar, A. S. “Stabilization of Residual Soil with Rice Husk Ash and Cement.” Construction and Building Materials, Vol. 19, No. 6, 2005, pp. 448–453. doi:10.1016/j.conbuildmat.2004.08.001.
Adhikary, S., and Jana, K. “Potentials of Rice-Husk Ash as a Soil Stabilizer.” International Journal of Latest Research in Engineering and Technology, Vol. 2, No. 2, 2016, pp. 40–42.
Choobbasti, A. J., Ghodrat, H., Vahdatirad, M. J., Firouzian, S., Barari, A., Torabi, M., and Bagherian, A. “Influence of Using Rice Husk Ash in Soil Stabilization Method with Lime.” Frontiers of Earth Science in China, Vol. 4, No. 4, 2010, pp. 471–480. doi:10.1007/s11707-010-0138-x.
Behak, Leonardo. “Soil Stabilization with Rice Husk Ash.” Rice - Technology and Production (March 22, 2017). doi:10.5772/66311.
Wong (2013b), L. S., Hashim, R., and Ali, F. “Improved Strength and Reduced Permeability of Stabilized Peat: Focus on Application of Kaolin as a Pozzolanic Additive.” Construction and Building Materials, Vol. 40, 2013, pp. 783–792. doi:10.1016/j.conbuildmat.2012.11.065.
Kolovos, K. G., Asteris, P. G., Cotsovos, D. M., Badogiannis, E., and Tsivilis, S. “Mechanical Properties of Soilcrete Mixtures Modified with Metakaolin.” Construction and Building Materials, Vol. 47, 2013, pp. 1026–1036. doi:10.1016/j.conbuildmat.2013.06.008.
Ahmed, M. D., and Hamza, N. A. “Effect of Metakaolin on the Geotechnical Properties of Expansive Soil.” Journal of Engineering, Vol. 21, No. 12, 2015, pp. 29–45.
Wikipedia contributors. Fly Ash. Wikipedia, The Free Encyclopedia. Available online: https://en.wikipedia.org/wiki/Fly_ash (accessed on 27 Dec., 2019).
Moayedi, H., Huat, B. B. K., Kazemian, S., and Daneshmand, S. “Stabilization of Organic Soil Using Sodium Silicate System Grout.” International Journal of Physical Sciences, Vol. 7, No. 8, 2012, pp. 1395–1402. doi:10.5897/IJPS11.1509.
Tastan, E. O., Edil, T. B., Benson, C. H., and Aydilek, A. H. “Stabilization of Organic Soils with Fly Ash.” Journal of Geotechnical and Geoenvironmental Engineering, Vol. 137, No. 9, 2011, pp. 819–833. doi:10.1061/(ASCE)GT.1943-5606.0000502.
Kolay, P., Sii, H., and Taib, S. “Tropical Peat Soil Stabilization Using Class F Pond Ash from Coal Fired Power Plant.” International Journal of Civil and Environmental Engineering, Vol. 3, No. 2, 2011, pp. 79–83.
Kolay, P., and Suraya, N. Stabilization of Organic Soil by Different Types of Stabilizer. In International Conference on Civil Engineering in the New Millennium: Opportunities and Challenges, Bengal Engineering and Science University, Shibpur, India, No. 3, 2007, pp. 1394–1400.
Nath, B. D., Molla, Md. K. A., and Sarkar, G. “Study on Strength Behavior of Organic Soil Stabilized with Fly Ash.” International Scholarly Research Notices, Vol. 2017, 2017, pp. 1–6. doi:10.1155/2017/5786541.
Pathak, A. K., Pandey, V., Murari, K., and Singh, J. P. “Soil Stabilisation Using Ground Granulated Blast Furnace Slag.” Int. Journal of Engineering Research and Applications, Vol. 4, No. 5, 2014, pp. 164–171.
Åhnberg, H. Strength of Stabilised Soils: A Laboratory Study on Clays and Organic Soils Stabilised with Different Types of Binder. Thesis. Lund University, Lund, 2006.
Wong, L. S., Roslan, H., and Faisal, A. “Unconfined Compressive Strength Characteristics of Stabilized Peat.” Scientific Research and Essays, Vol. 6, No. 9, 2011, pp. 1915–1921. doi:10.5897/SRE10.060.
Wong (2011a), L. S., Roslan, H., and Faisal, A. “Unconfined Compressive Strength Characteristics of Stabilized Peat.” Scientific Research and Essays, Vol. 6, No. 9, 2011, pp. 1915–1921. doi:10.5897/SRE10.060.
Axelsson, K., Johansson, S.-E., and Andersson, R. “Stabilization of Organic Soils by Cement and Puzzolanic Reactions–Feasibility Study.” Swedish Deep Stabilization Research Centre, Report, Vol. 3, 2002, pp. 1–51.
Kalantari, B., Prasad, A., and Huat, B. B. K. “Stabilising Peat Soil with Cement and Silica Fume.” Proceedings of the Institution of Civil Engineers - Geotechnical Engineering, Vol. 164, No. 1, 2011, pp. 33–39. doi:10.1680/geng.900044.
Kalantari, B., and Prasad, A. “Strength Evaluations for Treated Peat with Cement and Polypropylene Fibres Using CBR Tests.” 2013, p. 6.
Alhassan, M. “Potentials of Rice Husk Ash for Soil Stabilization.” Technical Report, 2008, p. 5.
Della, V. P., Kühn, I., and Hotza, D. “Rice Husk Ash as an Alternate Source for Active Silica Production.” Materials Letters, Vol. 57, No. 4, 2002, pp. 818–821. doi:10.1016/S0167-577X(02)00879-0.
Seco, A., F. Ramirez, L. Miqueleiz, P. Urmeneta, B. Garca, E. Prieto, and V. Oroz. “Types of Waste for the Production of Pozzolanic Materials – A Review.” Industrial Waste (March 7, 2012). doi:10.5772/36285.
Bui, L. A., Chen, C., Hwang, C., and Wu, W. “Effect of Silica Forms in Rice Husk Ash on the Properties of Concrete.” International Journal of Minerals, Metallurgy, and Materials, Vol. 19, No. 3, 2012, pp. 252–258. doi:10.1007/s12613-012-0547-9.
Behak, L. Soil Stabilization with Rice Husk Ash. In Rice - Technology and Production (Amanullah and S. Fahad, eds.), InTech.
Zain, M. F. M., Islam, M. N., Mahmud, F., and Jamil, M. “Production of Rice Husk Ash for Use in Concrete as a Supplementary Cementitious Material.” Construction and Building Materials, Vol. 25, No. 2, 2011, pp. 798–805. doi:10.1016/j.conbuildmat.2010.07.003.
Basha, E. A., Hashim, R., Mahmud, H. B., and Muntohar, A. S. “Stabilization of Residual Soil with Rice Husk Ash and Cement.” Construction and Building Materials, Vol. 19, No. 6, 2005, pp. 448–453. doi:10.1016/j.conbuildmat.2004.08.001.
Moayedi, Hossein, Babak Aghel, Mu’azu Mohammed Abdullahi, Hoang Nguyen, and Ahmad Safuan A Rashid. “Applications of Rice Husk Ash as Green and Sustainable Biomass.” Journal of Cleaner Production 237 (November 2019): 117851. doi:10.1016/j.jclepro.2019.117851.
Choobbasti, A. J., Ghodrat, H., Vahdatirad, M. J., Firouzian, S., Barari, A., Torabi, M., and Bagherian, A. “Influence of Using Rice Husk Ash in Soil Stabilization Method with Lime.” Frontiers of Earth Science in China, Vol. 4, No. 4, 2010, pp. 471–480. doi:10.1007/s11707-010-0138-x.
Roy, A. “Soil Stabilization Using Rice Husk Ash and Cement.” International Journal of Civil Engineering Research, Vol. 5, No. 1, 2014, pp. 49–54.
Rahman, Z. A., Ashari, H. H., Sahibin, A., R., Tukimat, L., and Razi, I. W. M. “Effect of Rice Husk Ash Addition on Geotechnical Characteristics of Treated Residual Soil.” American-Eurasian J. Agric. & Environ. Sci., Vol. 14, No. 12, 2014, pp. 1368–1377.
Wikipedia contributors. Kaolinite. Wikipedia, the Free Encyclopedia. Available online: https://en.wikipedia.org/w/index.php?title=Kaolinite&oldid=877920516 (accessed on 27 Dec., 2018).
Rana, J., and Rughooputh, R. “Partial Replacement of Cement by Ground Granulated Blast Furnace Slag in Concrete.” Journal of Emerging Trends in Engineering and Applied Sciences, Vol. 5, No. 5, 2014, pp. 340–343.
Wong (2013a), L. S., Hashim, R., and Ali, F. “Utilization of Sodium Bentonite to Maximize the Filler and Pozzolanic Effects of Stabilized Peat.” Engineering Geology, Vol. 152, No. 1, 2013, pp. 56–66. doi:10.1016/j.enggeo.2012.10.019.
Rashad (2013a), A. M. “Metakaolin as Cementitious Material: History, Scours, Production and Composition – A Comprehensive Overview.” Construction and Building Materials, Vol. 41, 2013, pp. 303–318. doi: 10.1016/j.conbuildmat.2012.12.001.
Poon, C. S., Lam, L., Kou, S. C., Wong, Y. L., and Wong, R. “Rate of Pozzolanic Reaction of Metakaolin in High-Performance Cement Pastes.” Cement and Concrete Research, Vol. 31, No. 9, 2001, pp. 1301–1306. doi:10.1016/S0008-8846(01)00581-6.
Hassan, Z. A., Daud, M. N. M., Yahya, Mu. A., and Shaharuddin, M. S. “Effect of Granular Material on the Rate of Consolidation of Peat Soil.” Electronic Journal of Geotechnical Engineering, Vol. 18, No. Bund. Z, 2013, pp. 6113–6123.
Wong, L. S., Hashim, R., and Ali, F. H. “A Review on Experimental Investigations of Peat Stabilization.” Australian Journal of Basic and Applied Sciences, Vol. 3, No. 4, 2009, pp. 3537–3552.
Wong (2011b), L. S., Hashim, R., and Ali, F. “Effect of Binder and Silica Sand on Unconfined Compressive Strength of Cemented Peat.” International Journal of the Physical Sciences, Vol. 6, No. 13, 2011, pp. 3047–3053.
DOI: 10.28991/cej-2020-03091479
Refbacks
- There are currently no refbacks.
Copyright (c) 2020 John Kok Hee Wong, Sien Ti Kok, Soon Yee Wong
This work is licensed under a Creative Commons Attribution 4.0 International License.
